Product ID:6409-L-16473, LEAD FREE GRAY
MSDS Date:08/07/1991
FSC:8010
NIIN:00N033309
MSDS Number: BPLYW

CARDINAL INDUSTRIAL FINISHES

1329 POTRERO AVE SOUTH
EL MONTE, CA 91733
US

Emergency Phone: 818-444-9274

Info Phone: 818-444-9274

Preparer: RICHARD STEWART

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

10 @ 68F.

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 10%

OSHA PEL 150 PPM;200 STEL

ACGIH TLV: 150 PPM;200 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

2.1 @ 68F.

CAS: 110-43-0

RTECS: MJ5075000

Fraction By Weight: 15%

OSHA PEL 100 PPM

ACGIH TLV: 50 PPM

70 @ 68F.

CAS: 78-93-3

RTECS: EL6475000

Fraction By Weight: 2%

OSHA PEL 200 PPM;300 PPM STEL

ACGIH TLV: 200 PPM;300 PPM STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

396 G/L

RTECS: 9999999VO

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: SEVERE EYE IRRITATION, REDNESS,
TEARING, AND BLURRED VISION. CAN CAUSE MODERATE SKIN IRRITATION,
DEFATTING, DERMATITIS AND TINGLING SENSATION. CHRONIC: MAY PRODUCE
LIVER AND KIDNEY DAMAGE, PERS ISTANT COUGHING, BRAIN DAMAGE AND
EVEN DEATH.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:INHAL:HDCH, FATIGUE, NAUS, VOMIT, DIZZ, STUPOR,
DROW, DISTURBED VISION, COUGHING, AND UNCON. SKIN: PRLNGD CONT CAN
CAUSE MOD IRRIT, DEFAT, & DERM. EYE: CAN CAUSE SEV IRRIT, REDNESS,
TEARING & BLURRED VISION. INGEST: BRTH SMELLS OF SOLV. IRRIT OF
LIPS & MOUTH. GI IRRIT, NAUS, DIARR, DROW, LOSS OF CONSCIOUSNESS,
(SUPDAT)
Medical Cond Aggravated by Exposure:PRE-EXISTING RESPIRATORY
CONDITIONS, PRE-EXISTING SKIN DISORDERS, LIVER AND KIDNEY
DISORDERS.

First Aid:EYES: FLUSH WITH PLENTY OF H*2O FOR AT LEAST 15 MIN. GET MED
ATTN. SKIN: WASH EXPOSED AREA WITH MILD SOAP AND WATER FOR 15
MINUTES. REMOVE CONTAMINATED CLOTHING. INHALATION: REMOVE TO FRESH
AIR. IF BR EATHING IS DIFFICULT, ADMINISTER OXYGEN. IF BREATHING
HAS STOPPED, GIVE ARTF RESP. GET MEDICAL ATTENTION. INGESTION: DO
NOT INDUCE VOMITING. KEEP VICTIM WARM AND SEEK IMMEDIATE MEDICAL
ATTENTION.

Flash Point Method:TCC
Flash Point:24F,-4.4C
Lower Limits:1.1%
Upper Limits:11.4%
Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. ISOLATE FROM
HEAT,SPARKS,ELEC EQUIP & OPEN FLAME.CLSD CNTNRS MAY EXPLO WHEN
EXPOS TO EXTREME HEAT.DURING EMER CNDTNS, OVEREXP (SUPDAT)

Spill Release Procedures:FOLLOW INSTRUCTIONS TO PREVENT HEALTH HAZARDS.
ELIMINATE ALL SOURCES OF IGNITION. ABSORB LIQUIDS IN ABSORBANT
MATERIAL AND PREVENT SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CNTNRS MAY BE HAZ WHEN EMPTIED. SINCE
EMPTIED CNTNRS MAY RETAIN PROD RESIDUALS (VAPS, LIQ, &/OR SOLIDS),
ALL PREC GIVEN IN MSDS MUST BE OBSERVED.
Other Precautions:STORE AT ROOM TEMP AWAY FROM HEAT SOURCES,& HAVE LIDS
TIGHTLY CLSD. OVEREXP HAS APPARENTLY BEEN FOUND TO CAUSE FOLLOWING
EFTS IN LAB ANIMALS: LIVER ABNORM, KIDNEY DMG,LUNG DMG,ALSO OVEREXP
TO MATL HAS BEEN SUGGESTED AS CAUSE OF (SUPDAT)

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED A
NIOSH/MSHA APPRVD SUPPLIED RESP IS ADVISED IN ABSENCE OF ENVIRON
CNTRL.OSHA REGS ALSO PERMIT OTHER NIOSH/MSHA APPRVD RESP UNDER
SPECIFIED CNDTNS. (SEE SAFETY EQUIP SUPP) ENGINEERING/ADMIN
(SUPDAT)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV'S.
Protective Gloves:POLYVINYL ALCOHOL COATED/POLYETHYLENE.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:PVNT REPEATED OR PROLONGED SKIN CONTACT WITH
GB PROTECTIVE HANDCREAM, WEAR IMPERVIOUS CLOTHING AND CHEM
RESISTANT BOOTS.
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING REST ROOM,
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
EXPLO HAZ: TO DECOMP PRODS MAY CAUSE HLTH HAZ.SYMP MAY NOT BE IMMED
APPARENT.OBTAIN MED ATTN. HLTH HAZ: STATE OF SHOCK, WEAK & RAPID
PULSE, COLD-PALE COMPLEXION. OTHER PREC: FOLLOWING EFTS IN HUMANS:
CARD ABNORM, LIVER ABNORM, KIDNEY DMG,&LUNG DMG. RESP PROT: CNTRLS
SHOULD BE IMPLEMENTED TO REDUCE EXPOSURE.

Boiling Pt:B.P. Text:>175F,>79C
Vapor Pres:SEE INGRED
Vapor Density:HVR/AIR
Spec Gravity:1.4 (H*2O=1)
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:NON SOLUBLE
Appearance and Odor:SOLVENT ODOR.

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS.
Stability Condition to Avoid:EXTREMELY HIGH TEMPERATURES.
Hazardous Decomposition Products:HAZARDOUS DECOMPOSITION MAY PRODUCE
CO*2 AND/OR CO.

Waste Disposal Methods:RECYCLE LIQUIDS IF POSSIBLE. INCINERATE SOLIDS
IN ACCORDANCE WITH APPLICABLE REGULATIONS. AS LAST RESORT
NEUTRALIZE AND LANDFILL IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.